Buckeye High School Commercial Roof Restoration in Medina, Ohio
Project Overview
Location: Medina, Ohio
Facility: Buckeye High School
Roofing Systems: Spray Polyurethane Foam (SPF) Roofing & Silicone Roof Coating System
Warranty: 20-Year Renewable, Non-Prorated, No Dollar Limit (NPR/NDL) Warranty
When a commercial roof begins showing its age, building owners are often faced with an important question:
Can the roof be restored, or does it need to be replaced?
At Buckeye High School in Medina, Ohio, the answer depended on the condition of each individual roof section.
Rather than recommending a complete roof replacement across the entire campus, West Roofing Systems developed a restoration plan that combined silicone roof coating systems with spray polyurethane foam (SPF) roofing.
This approach allowed the school district to restore multiple roof areas while investing additional work only where it was truly needed.
Understanding the Existing Roof System
Large school campuses rarely have one continuous roof.
Over the years, additions, renovations, and repairs often result in multiple roofing systems across a single facility.
Following a detailed inspection with school representatives, our team evaluated each roof section individually.
Several areas remained in good enough condition to be restored using a high-performance silicone roof coating system.
Other sections required additional rehabilitation. In those locations, the existing top roofing layer was removed to expose the original built-up roof before installing a new spray polyurethane foam roofing system.
Matching the roofing solution to each roof's condition helped maximize the district's investment while extending the service life of the campus roofing systems.
Preparing the Roof for Restoration
Every successful roof restoration starts with proper preparation.
For roof sections receiving silicone coatings, our crews thoroughly cleaned the existing roofing membranes using high-pressure water to remove dirt, oxidation, and contaminants that could affect adhesion.
Roof sections receiving spray polyurethane foam required additional preparation.
After removing deteriorated roofing materials, the remaining built-up roof surface was cleaned and inspected before foam application.
Throughout the project, rooftop equipment, piping, HVAC units, vents, and other rooftop components were carefully protected to ensure a clean, professional installation.
Any areas of wet insulation or deteriorated decking discovered during construction would have been replaced to ensure the restored roof system was installed over a sound substrate.
Two Roofing Systems, One Long-Term Solution
One unique aspect of this project was combining two proven commercial roofing systems.
Silicone Roof Coating Restoration
Roof sections that remained structurally sound were restored using a premium high-solids silicone roof coating system.
Before coating, each roof received the appropriate surface preparation, including primers or bleed-blocking materials where required.
Flashings, penetrations, and roof details were reinforced with compatible silicone sealants.
The silicone coating system was then installed to a total thickness of approximately 30 mils, creating a seamless waterproof membrane designed to withstand ponding water, harsh weather, and years of UV exposure.
Several roof sections also received quartz aggregate embedded into the coating surface to improve durability and provide additional traction for rooftop foot traffic.
Spray Polyurethane Foam Roofing
Roof sections requiring additional restoration were sprayed with polyurethane foam.
After removing the deteriorated roofing layer, approximately 1.5 inches of closed-cell spray polyurethane foam was applied directly to the existing roof.
Unlike traditional roofing materials, SPF creates a seamless insulation layer that fully adheres to the roof surface.
During installation, the foam can also be shaped to improve drainage and eliminate low areas where water might otherwise collect.
Once the foam was installed, it received the same high-performance silicone coating system used throughout the project.
These roof sections were finished with ceramic roofing granules embedded into the silicone topcoat, creating a durable walking surface while providing additional protection against weathering and ultraviolet exposure.
Attention to Every Detail
Roof restoration is about much more than installing coatings.
As part of this project, new perimeter edge metal was installed where necessary to ensure proper integration with the new roofing systems.
New 24-gauge Kynar-painted gutters and downspouts were also installed on selected roof sections to improve water management and complement the restored roof.
Throughout construction, the project was supervised by an OSHA 30-hour-trained superintendent, helping ensure safety and quality from start to finish.
When the installation was complete, all construction debris and excess materials were removed, leaving the property clean and ready for normal school operations.
A 20-Year Renewable Roofing System
One of the biggest advantages of restoring the Buckeye High School roof was the long-term protection it provides.
Upon completion, the school district received a 20-year Full System Non-Prorated (NPR), No Dollar Limit (NDL), Renewable warranty.
Rather than simply repairing isolated roof problems, the district now has a restored roofing system designed to provide decades of dependable performance while eliminating the need for a costly tear-off and replacement.
Why School Districts Choose Roof Restoration
For many educational facilities, restoring an existing commercial roof can provide significant financial and operational benefits.
Instead of replacing a roof that still has a sound structural foundation, restoration can:
• Extend the service life of the existing roof
• Reduce capital expenditures compared to full replacement
• Improve waterproofing performance
• Increase insulation value on SPF roof sections
• Minimize disruption to students and staff
• Reduce construction waste sent to landfills
• Qualify for long-term renewable warranty protection
By taking action before roofs deteriorate beyond repair, school districts can preserve valuable roofing assets while making the most of limited maintenance budgets.
Commercial Roofing Contractor Serving Medina, Ohio
West Roofing Systems has helped schools, manufacturing facilities, warehouses, office buildings, and commercial property owners throughout Ohio restore aging commercial roofs for more than 45 years.
If your commercial roof is nearing the end of its service life, our team can determine whether restoration with a silicone roof coating system or spray polyurethane foam roofing can help you avoid the cost of a complete roof replacement.
Contact West Roofing Systems today to schedule a free commercial roof inspection and learn whether your building is a candidate for roof restoration.